罗伊氏乳杆菌制剂的制备及性能评价

刘博; 许毅; 秦世尚; 唐滋一; 徐辉; 乔代蓉; 曹毅

doi:10.13568/j.cnki.651094.2017.01.011

您当前的位置：

首页 >

文章列表页 >

罗伊氏乳杆菌制剂的制备及性能评价

更新时间：2026-01-21

- 罗伊氏乳杆菌制剂的制备及性能评价
- Journal of Xinjiang University (Natural Science Edition in Chinese and English) Vol. 34, Issue 1, Pages: 54-60(2017)
- 作者机构：
  
  四川大学生命科学学院微生物与代谢工程四川省重点实验室
- 作者简介：
- 基金信息：
- DOI：10.13568/j.cnki.651094.2017.01.011
  CLC： TS201.3
- Published：2017
- 稿件说明：
移动端阅览
[1]刘博,许毅,秦世尚,等.罗伊氏乳杆菌制剂的制备及性能评价[J].新疆大学学报(自然科学版),2017,34(01):54-60.
[1]刘博,许毅,秦世尚,等.罗伊氏乳杆菌制剂的制备及性能评价[J].新疆大学学报(自然科学版),2017,34(01):54-60. DOI： 10.13568/j.cnki.651094.2017.01.011.

DOI：10.13568/j.cnki.651094.2017.01.011.

摘要

罗伊氏乳杆菌(Lactobacillus reuteri)常栖息于人和动物的肠道系统中

能产生一种特殊的抑菌物质——罗伊氏素

是调节肠道功能的益生菌.乳酸菌活菌制剂广泛应用于食品、医疗、饲料等相关行业.喷雾干燥的能耗较低

在同样生产出优质产品的前提下

冷冻干燥消耗的能量是喷雾干燥的6～10倍.本文通过吸附材料的筛选、保护剂的选择

并对喷雾干燥相关条件进行优化

利用优化的条件进行罗伊氏乳杆菌制剂的制备

并对制备的乳酸菌制剂进行热稳定性实验以及相关质量测定(电镜观察、水分含量、粒径、得率等).结果表明

利用改性硅藻土作为吸附材料的乳酸菌制剂活菌存活率优于改性沸石

选定脱脂牛奶和果聚糖作为保护剂

最佳喷雾干燥条件为:进口温度120?C

出口温度60?C

脱脂牛奶10 g

果聚糖5 g

硅藻土5 g

通过此优化条件制备的乳酸菌制剂其活菌存活率达到88%

活菌数达到5.14×109CFU/g.该乳酸菌制剂在70?C条件下水浴1h

乳酸菌活菌数为3.49×106CFU/g.研究表明

通过优化的喷雾干燥条件制备的乳酸菌制剂存活率高

热稳定性较好.

Abstract

Lactobacillus reuteri often exists in the intestinal system of human and animals

which can produce a special kind of antibacterial substances-reuterin. Lactic acid bacteria living bacteria preparation is widely used in food

health care

feed and other related industries. Spray drying is of low energy consumption

the consumption of freeze drying energy is 6-10 times of spray drying under the same condition of good products.This paper selecting adsorption materials and protective agent

optimizing related conditions of spray drying

and then using the optimized conditions for preparation of lactobacillus reuteri

finally measuring the quality and do the thermal stability experiments of agent of lactobacillus reuteri(electron microscope

moisture content

particle size

yield

etc.). The research show that the survival rate is better when use the modified diatomite as adsorption material of lactic acid bacteria preparation than modified zeolite. When choose skim milk and fructan as protectant

the best spray drying conditions are:inlet temperature 120?C

outlet temperature 60?C

skim milk

10 g

fructan 5g

diatomite 5g. Through the optimization conditions of preparation of lactobacillus preparation

the living bacterium survival rate will reach 88%

and the number of living bacterium will achieve 5.14 x 109CFU/g. When change the lactic acid bacteria preparation under the condition of 70?C water bath for 1 h

lactic acid bacteria living bacterium number will be 3.49 x 106CFU/g.Therefore

the study finally conclude that through the optimization of the spray drying conditions will not only improve the survival rate of lactic acid bacteria

but also enhance the thermal stability.

关键词

Keywords

references

Buch K,Penning M,W¨achtersbach E,et al.Investigation of various shellac grades:additional analysis for identity[J].Drug development and industrial pharmacy,2009,35(6):694-703.

Burgain J,Gaiani C,Linder M,et al.Encapsulation of probiotic living cells:From laboratory scale to industrial applications[J].Journal of Food Engineering,2011,104(4):467-483.

Champagne C P,Raymond Y,Tompkins T A.The determination of viable counts in probiotic cultures microencapsulated by spray-coating[J].Food microbiology,2010,27(8):1104-1111.

Stummer S,Salar-Behzadi S,Unger F M,et al.Application of shellac for the development of probiotic formulations[J].Food research international,2010,43(5):1312-1320.

Basholli-Salihu M,Mueller M,Salar-Behzadi S,et al.Effect of lyoprotectants onβ-glucosidase activity and viability of Bifidobacterium infantis after freeze-drying and storage in milk and low p H juices[J].LWT-Food Science and Technology,2014,57(1):276-282.

Capela P,Hay T,Shah N.Effect of cryoprotectants,prebiotics and microencapsulation on survival of probiotic organisms in yoghurt and freeze-dried yoghurt[J].Food Research International,2006,39(2):203-211.

Kets E,Teunissen P,De Bont J.Effect of compatible solutes on survival of lactic Acid bacteria subjected to drying[J].Applied and Environmental Microbiology,1996,62(1):259-261.

Santivarangkna C,Kulozik U,Foerst P.Alternative drying processes for the industrial preservation of lactic acid starter cultures[J].Biotechnology progress,2007,23(2):302-315.

罗佳琦.嗜酸乳杆菌微胶囊化制备方法的研究[D].大连:大连理工大学,2009.

郭云,孟祥晨.喷雾干燥对发酵乳杆菌KLDS1.0709存活影响的研究[J].食品工业科技,2011(2):109-111.

Khem S,Small D M,May B K.The behaviour of whey protein isolate in protecting Lactobacillus plantarum[J].Food Chem,2016,190:717-23.

Views

418

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

No data

Related Author

No data

Related Institution

No data

⁰